Kia Picanto: Controller / Heater & A/C Control Unit(Manual)

Kia Picanto JA 2017-2024 Service & Repair Manual / Heating,Ventilation, Air Conditioning / Controller / Heater & A/C Control Unit(Manual)

Components and components location

Components

[NON ISG]

Connector pin function

No.	Connector A	Connector B
1	Low	Battery
2	Common	Illumination (+)
3	Ground	HTD
4	Middle (Low)	ISG Battery
5	Middle (High)	-
6	High	Detent out (-)
7		-
8		Sensor REF (+5V)
9		Intake actuator (FRE)
10		Intake actuator (REC)
11		Intake actuator Feedback
12		PAB On signal
13		PAB Off signal
14		Ground
15		Sensor ground
16		Illumination (-)
17		IGN2
18		IGN1
19		PAB IGN1
20		Ambient sensor (+)
21		Evaporator sensor (+)
22		MAX Blower on signal
23		Seat belt reminder
24		Rear left seat belt reminder
25		Rear center seat belt reminder
26		Rear right seat belt reminder
27		-
28		C_CAN (High)
29		C_CAN (Low)
30		Rear deffog switch
31		Blower on signal to Common
32		Ground

Repair procedures

Replacement

1.	Disconnect the negative (-) battery terminal.

2.	Remove the floor console assembly. (Refer to Body - "Floor Console Assembly")

3.	Remove the crash pad lower panel. (Refer to Body - "Crash Pad Lower Panel")

4.	Remove the driver's side shower duct (A) after loosening the screw.

5.	Disconnect the mode control cable (A).

6.	Remove the glove box housing. (Refer to Body - "Glove Box Housing")

7.	Remove the passenger's side shower duct (A) after loosening the screw.

8.	Disconnect the temperature control cable (A).

9.	After loosening the mounting screws, remove the A/C & heater controller unit (A).

10.	Disconnect the A/C & heater controller connectors (A).

11.	Install in the reverse order of removal.

Controller

...

Heater & A/C Control Unit(Full Automatic)

Components and components location Components Control Panel Connector pin function No. Connector A Con ...

Other information:

Kia Picanto JA 2017-2024 Owner's Manual: Rear parking assist system precautions

The rear parking assist system may not sound consistently depending on the speed and shapes of the objects detected. The rear parking assist system may malfunction if the vehicle bumper height or sensor installation has been modified or damaged. Any non-factory installed eq ...

Kia Picanto JA 2017-2024 Owner's Manual: Indicator Lights

Electronic Stability. Control (ESC) Indicator Light This indicator light illuminates: Once you set the ignition switch or Engine Start/Stop Button to the ON position. - It illuminates for approximately 3 seconds and then goes off. When there is a malfunction with the ESC sy ...