Kia Picanto: General Information / Warning And Caution Labels
General information
Warning And Caution Labels |

1. Cooling fan caution 2. Radiator cap caution
| 3. Battery caution
|
Battery Caution Label

Warning / Caution Label (Cont'd)
A. Keep lighted cigarettes and all other flames or sparks away from the battery.
|
B. Wear eye protection when charging or working near a battery. Always provide ventilation when working in an enclosed space.
•
| When
lifting a plastic-cased battery, excessive pressure may cause leakage
of acid resulting in possible personal injury. To avoid this, lift in a
battery carrier or by holding opposite corners. |
•
| Never attempt to change the battery when the battery cables are connected. |
•
| The electrical ignition system works with high voltage. Never touch these components with the engine running or the ignition switched on. |
|
C. Keep
batteries out of the reach of children because batteries contain highly
corrosive SULFURIC ACID. Do not allow battery acid to contact your
skin, eyes, clothing or paint finish.
|
D. If
any electrolyte gets into your eyes, flush your eyes with clean water
for at least 15 minutes and get immediate medical attention. If
possible, continue to apply water with a sponge or cloth until medical
attention is received. If electrolyte gets on your skin, thoroughly
wash the contacted area. If you feel a pain or a burning sensation, get
medical attention immediately.
|
E. Always read the following instructions carefully when handling a battery.
|
F. Hydrogen, a highly combustible gas, is in battery cells at all times, and may explode if ignited.
|
G. An improperly disposed battery can be harmful to the environment and human health. Always conform to local regulations for battery disposal.
|
Handling and Storing Battery
Battery Itself
| •
| Batteries should be stored in cool, dry (27 degrees Celsius) places and out of direct sunlight. |
•
| MF batteries are tightly sealed to prevent acid leakage. However,
tilting the battery to an angle of 45º or over may cause acid leakage
through the vents on the sides. Therefore, store batteries in the
upright position.Prevent placing any aqueous or solid (i.e. conductors)
bodies on top of the battery. |
•
| It
is extremely dangerous to use tools, such as hammers, on the battery
terminals when connecting cables to the mounted battery. |
|
Battery on Vehicle
| •
| When
storing the vehicle for a long period of time, make sure to remove the
memory fuse at the junction box to prevent natural discharging. |
•
| Also,
charge the battery by running the engine within 1 month if the memory
fuse hasn't been removed since the start of vehicle storage. If
the memory fuse has been removed, charge the battery by running the
engine within 3 months from the start of vehicle storage. |
|
After reconnecting or recharging a discharged battery, the ESP OFF indicator may illuminate. In this case, turn the handle half way to the left and right whilst the ignition switch is in the ON position. Then, restart the engine after the ignition is OFF. The ESP OFF indicator may turn OFF. If the ESP OFF indicator does not turn OFF, have the system checked refering to DTC. |
General information
Identification Number
Identification Number Description
Vehicle Identification Number
1. World Manufacturer Identifier (WMI) - KNA : Passenger vehicle, MPV(Multipur ...
General information
Lift And Support Points
When
heavy rear components such as suspension, fuel tank, spare tire,
tailgate and trunk lid are to be removed, place addit ...
Other information:
Repair procedures
Operation and Leakage Check
Check all of the following items:
Component
Procedure
Brake Booster (A) Check
brake operation by applying the brakes during a test drive. If the
brakes do not work properly, che ...
Repair procedures
Replacement
1.Remove the crankshaft damper pulley.
(Refer to Drive Belt System - "Crankshaft Damper Pulley")
2.Remove the crankshaft front oil seal (A).
3.Using the SST (09214-1R100, 09231-H1100), install a new front oil seal, apply engine ...